One way to increase the speed of EZ Go golf carts is to incorporate an octane booster when you fill the tank. The cart will have more pick-up, and it could gain as much as 5 mph. A different approach is to take out the throttle linkage governor on the carburetor.
Moreover, how do you remove the speed limiter on a EZ Go golf cart?
Subsequently, how do you adjust the governor on a gas golf cart? If you find this rod, then your governor can be easily adjusted by accessing the cart’s inner workings. Simply adjust the cable coming from this metal protrusion, turning the nut counterclockwise to make the cable longer, effectively adjusting the cart’s governance to increase the overall speed.
Amazingly, can you make a gas golf cart go faster? Increase the RPM An increase in the input shaft rpm for all differential ratios will produce a higher speed. For a gas golf cart, other than adjusting the governor, the speed may be enhanced by replacing the engine with a higher rpm output model.
Likewise, how fast does a gas EZ GO golf cart go? The fastest gasoline Club Car only goes 19 mph. And the fastest electric EZGO is the 2Five that goes 25 mph. And the fastest EZGO gasoline golf cart also only goes 19 mph.
- Locate the governor arm mounted on top of the rear axle case underneath the cart.
- Loosen the adjusting locknut on the end of the governor spring.
- Retighten the adjusting locknut.
How do you adjust the governor on a EZ Go golf cart?
Basically, an electric speed governor can be controlled by a tiny metal rod that’s located by the clutch of your golf cart. First things first: The electric speed governor is connected to a cable. You can adjust your speed by rotating the nut in a counterclockwise rotation.
Why is my golf cart so slow?
Low Battery Usually, the most common reason golf carts slow down is when they don’t get enough power output from the battery. If the battery pack charge is very low and your cart is out of power, your cart will run slow.
How do I adjust my EZ Go carburetor?
2 Cycle engine: The adjustment screw is on the side of the carburetor and is parallel to the ground. You can identify it by the lock nut at the base of the screw. Loosen this and turn the screw all the way into a soft seat, then back it out one and a half (1-1/2) turns.
Is 30 mph fast for a golf cart?
Depending on how far you want to go on a full charge, you might want a 40mph or a 30mph golf cart. At top speed, most golf carts do around 14mph. However, with the advent of street legal golf carts and modifications, it is possible to go 35mph and above.
How do I get more torque out of my gas golf cart?
Change the Speed ControllerThe Speed Controller regulates the electric output of the motor; a higher voltage equals more RPM, and the faster your cart will travel. When you change the speed controller, you can reduce the voltage and increase the amperage of the motor, resulting in increased torque.
How fast does a 36V golf cart go?
Standard 36V and 48V golf carts are capable of the same top-end speed (12MPH). You can, however, make your golf cart go faster by doing a couple of things: Larger Tires – You can purchase larger tires.
How do you put a speed chip in a EZ Go golf cart?
Who makes the fastest gas golf cart?
The fastest EZGO gas cart will top out at 19 mph. Overall, the 3 fastest electric carts, besides the 2Five, are the STAR Sirius 2+2, which is produced in the United States, and the Chinese manufactured ECO Drive 2+2 and ECO Plus 2+2. Both of these models have a top speed of 25 mph.
Is there a governor on an ezgo electric golf cart?
One thing that electric cart owners find themselves wondering, however, is how do you make an electric golf cart faster? … Considering electric golf carts don’t have governors like gas powered carts, the old-school method of simply removing the governor is not an option.
Where is the speed sensor on a ezgo golf cart?
Typically, the speed sensor can be found on the backside of the motor. When removing the speed sensor, unplug all the cables that are on the backside of the motor. To do this, use a socket to take off the connector pigtail. Then, remove its plastic housing over the sensor.
How do you check the ezgo inductive throttle sensor?
Put the key in the “On” position in your Run/Tow switch on the cart. Switch the F/R switch into a forward position to test your cart. Place your voltimeter testing pins on the throttle pins to see how much voltage you get. When the cart is running with no throttle, you should get about 10 volts here.
Why does my golf cart slow down going uphill?
The Reason Your Electric Golf Cart Goes Slow Uphill? Your electric golf cart can struggle on inclines for a variety of reasons. Weak batteries, incorrect tires, and wear and tear to the motor and wiring are all potential causes of your cart’s slow speed.
Why does my ezgo backfire?
The Throttle May Not Be Closing Properly. A gas-powered golf cart utilizes a handful of different parts that help to keep the fuel flow smooth. When the fuel flow isn’t properly handled, there is a strong chance of a backfire affecting your cart.
How do you clean the carburetor on a EZ Go golf cart?
Why does my ezgo golf cart backfire?
In almost all cases, whether it is a 2 cycle or 4 cycle engine, golf cart backfiring is caused by the accelerator cable being out of adjustment at the throttle plate of the carburetor. This problem has a relatively simple cure.
What’s the top speed of a golf cart?
What is the Average Golf Cart Speed? The average top speed of a typical golf cart without any upgrades is between 12 and 14 miles per hour. Without any sort of modification or upgrade on a golf cart, the top speed that you will be getting on a golf cart is about 14mph.
Which golf cart is the fastest?
One group of “speed fiends” currently leading the industry in fast golf cart builds is Plum Quick Golf Cart Racing. The company currently holds two Guinness World Records and numerous other awards. One of these records is the world record for fastest golf cart. Traveling at 118.76 mph this cart can outrun most cars.
What does a speed controller do on a golf cart?
The controller meters out current and voltage on your battery based on user input, whether that be a gas pedal, a throttle, or even pedals on a bicycle. With the controller you are able to control your acceleration and deceleration, as well as the speed at which your vehicle moves.
Can I put 48V in my 36V golf cart?
It all depends on your battery bank used with this 36V to 48V conversion. can only be accomplished through installing a 48V motor capable of higher torque, or installing a 48V controller with a higher current limit (amperage). When DC power is discussed, amperage equals torque and voltage equals speed.
How much torque does a gas golf cart have?
The gas version of the exact same cart can produce 14HP with only 19.91 lb-ft of torque @ 2400 RPM. These are the MAX gas specifications.
How can I make my Gas Club Car DS faster?
Is 48V better than 36V?
It is pretty simple to understand. A 36V e-bike battery will allow you to draw a lesser critical current, typically around 15 amperes whereas, a 48V e-bike battery will allow more current in the range of 10 – 40 amperes. It means you can go faster with a 48V E-bike battery.
How do I know if my EZ Go is PDS?
The easiest way to determine if you have a PDS or not is by examining the environmental black plastic cover which houses the controller and solenoid. If it has a series of diagnostic codes listed on the outside, it is most definitely a PDS system.
What is an EZ Go personality plug?
The Personality Plug for your E-Z-GO PDS (Precision Drive System) allows you to change the operational drive features of your vehicle for enhanced speed up to 18 mph when driving on various terrain.
What is a golf cart personality chip?
The Freedom “High Speed” personality chip will increase your golf carts speed by 2-5 MPH. The chip works with 36-volt EZGO 2000+ TXT golf carts with PDS (Precision Drive System) only. This will NOT work with 48V systems on 2008+ carts.
